folks, its my first time and with cold months upon us I figure i will start disassembly of my interior to send to Autos Int for restoration. Headliner and carpets are already done, i just want to remove seats, door panels, door top rails, rear top rails, rear shelf and dash pad. If any of you have been down this road pls share any YouTube videos that will help, any articles from this registry, books, best/must have tools, etc, thanks in advance robb gwaltney
PS, also want to install carpet kit in my 71 911T coupe, dynamat already installed, same type of reference sources needed, also what glue do u guys recommend, thanks, robb
Removal of Interior/62B Coupe to Autos International
-
- 356 Fan
- Posts: 130
- Joined: Fri Sep 02, 2016 10:40 am
- Location: Powhatan, Virginia
Removal of Interior/62B Coupe to Autos International
Robb Gwaltney
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
-
- 356 Fan
- Posts: 44
- Joined: Sun Sep 14, 2014 11:57 am
Re: Removal of Interior/62B Coupe to Autos International
I just finished removing the interior out of my 63b and it was pretty straight forward. A phillips and standard screwdriver an interior prying tool and a thin long punch was all I needed to get it all out. Dash Pad, top rails, and door cards all come off with screws mostly all visible. Door handles and window crank have a small pin in them you tap out with a punch and then remove the door cards after removing the screws. For the seats make sure the rails are clean and have some lube in them and slide the all the way forward to come out of the rails. You can remove the upper potion of the driver if needed. For the rear panels you could also use a small amount of heat to loosen any adhesive when removing them. Theres like 100 screws it seems like so keep them bagged and tagged as you go! I had mine out in a few hours plus a snack/smoke break. way easeir to remove than any modern interior with clips etc, not much to mess up. I would say the headliner and carpet were more difficult so youre good!
-
- 356 Fan
- Posts: 130
- Joined: Fri Sep 02, 2016 10:40 am
- Location: Powhatan, Virginia
Re: Removal of Interior/62B Coupe to Autos International
thanks Mark for the insight, according to local restoration shop, the engine needs to come out to remove the rear panel to access the backside of the clips, did u run into issues removing rear panel?
Robb Gwaltney
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
-
- 356 Fan
- Posts: 44
- Joined: Sun Sep 14, 2014 11:57 am
Re: Removal of Interior/62B Coupe to Autos International
My car is being fully taken apart so the engine was out, good point. There will be studs on the rear panel poking through to the engine bay held on with these circular clip nuts, ( someone will chime in with their correct term) They stick through the engine insulation, you may be able to remove them with a big hassle with the engine still in but it would be tricky. A foot or two long pry fork or long needle nose maybe but it would be really tight. Depending on your set up you could drop the engine pretty easily and do it but understand not wanting to take the car apart more if you dont have to.
The only thing I can think of is being able to cut the clips off with long cutters and the pull the panel off. Best of luck bud
The only thing I can think of is being able to cut the clips off with long cutters and the pull the panel off. Best of luck bud
-
- 356 Fan
- Posts: 130
- Joined: Fri Sep 02, 2016 10:40 am
- Location: Powhatan, Virginia
Re: Removal of Interior/62B Coupe to Autos International
got it thanks Mark
Robb Gwaltney
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
- Robert Reed
- 356 Fan
- Posts: 309
- Joined: Thu Dec 08, 2011 3:18 pm
- Location: Lascassas, TN
Re: Removal of Interior/62B Coupe to Autos International
Robert; I don’t know if you’v found them yet, a screw behind the rubber for the rear garnish piece below the rear side glass...
I wish that I could come up with other items of interest but I can’t think of others right now.
It does help to remove the steering wheel to remove the driver seat, especially if the rails are sticky.
Bob
I wish that I could come up with other items of interest but I can’t think of others right now.
It does help to remove the steering wheel to remove the driver seat, especially if the rails are sticky.
Bob
- Doug McDonnell
- 356 Fan
- Posts: 6084
- Joined: Sat Apr 05, 2008 8:21 am
- Location: Augusta,Michigan
Re: Removal of Interior/62B Coupe to Autos International
rear side panel clips: viewtopic.php?f=13&t=45612&hilit=side+panel+clips and rear firewall interior panel: viewtopic.php?f=1&t=32529&p=261634&hili ... el#p261634 I doubt that you will be able to remove and install the rear firewall panel with the engine in. I hope that original owner 62 you bought is being kind to you.
1965 356C 2000 BMW 740i Sport 1967 Honda CL77 There is never enough time to do it right, but always enough time to do it over.
- Doug McDonnell
- 356 Fan
- Posts: 6084
- Joined: Sat Apr 05, 2008 8:21 am
- Location: Augusta,Michigan
Re: Removal of Interior/62B Coupe to Autos International
Robb The original speed nuts were round and no longer available. If careful you may be able to save yours. Here is a link about them: viewtopic.php?f=1&t=40269&p=251770&hili ... ts#p251770
1965 356C 2000 BMW 740i Sport 1967 Honda CL77 There is never enough time to do it right, but always enough time to do it over.
-
- 356 Fan
- Posts: 130
- Joined: Fri Sep 02, 2016 10:40 am
- Location: Powhatan, Virginia
Re: Removal of Interior/62B Coupe to Autos International
Doug sorry i took christmas break from chat, thanks for the links and all the info, hope ur doing well, happy new year, i just got a 71T RS outlaw and having a blast with it, robb
Robb Gwaltney
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i
71 911 T Coupe RS Outlaw, white
62 356B Coupe Silver Metallic
95 HD FLSTN
2018 Porsche Macan Sport Edition
1998 E36 M3 track car
2007 BMW 650i